CLR I D 9.8.4 Intermediate products

In decision T 22/82 (OJ 1982, 341) the board ruled that the preparation of new intermediates for a surprisingly advantageous complete process for the preparation of known and desired end products was inventive.

Again in T 163/84 (OJ 1987, 301) intermediate chemical products were held to be patentable on the grounds that their further processing to the known end products involved an inventive step. The board however held that a new chemical intermediate did not become inventive merely because it was prepared in the course of an inventive multi-stage process and was further processed to a known end-product; there had to be other factors as well, such as that the process for preparing the new intermediate had enabled it to be prepared for the first time and had done so inventively and other methods of preparing it had appeared to be ruled out.

In T 648/88 (OJ 1991, 292) the board disagreed with the view expressed in T 163/84, pursuing instead the line taken in T 22/82. An intermediate intended for the preparation of a known end-product was deemed to be inventive if its preparation took place in connection with inventive preparation or inventive further processing or in the course of an inventive complete process (confirmed in T 1239/01).

In T 65/82 (OJ 1983, 327) it was explained that new intermediates which take part in (non-inventive) analogy processes for sequent products (i.e. end products or intermediates of various kinds), must – in order to qualify as intermediates – provide a structural contribution to the subsequent products. Even where this condition is met, such intermediates are not thereby unconditionally inventive, i.e. not without taking the state of the art into consideration. As state of the art in relation to intermediates there are two different areas to be taken into account. One is the "close-to-the-intermediate" state of the art. These are all compounds identified from their chemical composition as lying close to the intermediates. On the other hand the "close-to-the-product" state of the art must also be taken into account, i.e. those compounds identified from their chemical composition as lying close to the subsequent products.

In T 18/88 (OJ 1992, 107) the applicants had argued that the insecticidal activity of the known end products was significantly superior to that of another known insecticide with a similar structure; this was sufficient to establish an inventive step for the intermediate products, even if the end products were not novel and/or inventive. The board, referring to T 65/82 (OJ 1983, 327), rejected the applicants' argument on the following grounds: claimed intermediates must themselves be based on an inventive step to be patentable. Whether, under certain circumstances, new and inventive subsequent products might support an inventive step of intermediates was not the question here, because the subsequent products in this case were either not novel or not inventive. The superior effect of subsequent products which were neither novel nor inventive was not sufficient to render the intermediates inventive (T 697/96, T 51/98).

10 references found.

Click X to load a reference inside the current page, click on the title to open in a new page.

Case Law Book: I Patentability

General Case Law